I tried cleaning the original carb and putting it back on and it does the same thing. Re: Engine only runs with choke on No it doesn't. If i push the choke in any farther it dies.When i give it throttle it pops and stumbles and then catches. The exhaust is stock. I can push the choke in one notch and it'll kinda stumble idle at around 1,000 rpms. Yamaha G2 Golf Cart Only Runs When Choked. Specified plug:BPR6HS(NGK) 7DK-24164-10 OIL EF2000IS YAMAHA MOTOR POWERED PRODUCTS CO.,LTD. Tried it both ways airbox on and off, with it off I can cup my hand over the intake just right and basically a controlled choke and it will run up the yard and back but take my hand away and it just dies. Now when i start it,it still has to be on full choke but it only runs at 2,000 rpms now. Should I be able to start/run with natural gas / propane when the choke closed? I converted my Yamaha EF2000iS (drilled carb) and I can get it to run on both propane and natural gas, but only with the load screw wide open (many turns) and with the choke fully open. The major sign is the motor will only run on choke and will cough and gag when off choke. One cause could be an air leak on the carb, head gasket, crankshaft seal. Yamaha G1 Only Runs with Choke. http://uscarb.websitetoolbox.com/post/My-Generator-Will-Not-Run-On-Natural-Gas-6354112. Typically the loadblock (the brass tee with a black adjusting knob on the outlet of the regulator) should be 5-8 full turns out (all the way in then turned counterclockwise 5-8 full revolutions). Check for … Take the bowl off, dump out any gasoline that's in there. At an idle does the pilot mixture screw make a difference in running? Please enable JavaScript in your browser settings. Large images may take a few minutes to appear. As I said, it runs for 2 seconds then dies. Got nearly 5 hours (4:45 hrs + extra 5 min to intentionally run out fuel for shutdown via the petcock switch) on 2/3 a tank of gas each (1.1 gallon tank per generator). Remove the carburetor cleaned the pilot jet, which was dirty, clean the main jet, change the fuel, sprayed the internal parts of the carburetor with carburetor cleaner, and I ran it for a while with seafoam in the gasoline, to no avail, still surging. The carbs are running 132.5 mains. Purchased new in 2015. Page created in 0.069 seconds with 21 queries. Facebook. At work they have quite a few of them, once they leave the shop, maintenance is pretty much non existent, and no major problems. The total running time of machine would be about 5 hours. (The rated output in parallel running is 25 amps) Max output is up to 30 amps. Almost seems as if the engine isn't getting enough fuel. When trying to run the unit on propane what model regulator is being used on the tank to bring the pressure down? My son was riding his PW50 in the yard today and it was running great , and then all of a sudden it just died on him , it starts right back up and idles but when you give it gas it boggs down and acts like it is starving for fuel , I flipped the choke up to the first setting and it runs great with the choke on .. Also if the engine starts propane at let's say 5 turns then usually it will take 1-2 more turns counterclockwise for natural gas. Engine warmed up and as I start to close off the choke the revs start to drop and engine stops. Login with username, password and session length. It should raise and lower the idle speed slightly if it is working right. There will likely be a brown goo in the bowl and jet. The redesigned EF2000is has a new controller board which will allow you to run the generator at the maximum AC Output for a longer period of time before overloading. That dude just WANTS to run! If I hit the gas with choke off, it would just die, not rev. It runs with the choke on because the choke engages the "enricher" circuit. Many features may not work properly without it. Just got my first golf cart and I'm trying to resolve an issue with it. Vimeo,  Supported videos include: sounds for shure like you have a air/fuel ratio problem,,,check there first. It runs fine on gasoline with the choke closed. And that Honda 2000 is one of the best gens on the market today. Dailymotion,  Posted: Mon Jun 05, 2017 4:14 pm Post subject: Re: Honda Eu2000i only runs on choke: I have had my Eu2000i for six years,no issues yet. Restart can only be performed if the engine oil is replenished up to the specified level. Metacafe,  I will second sarge.. A clear sign that their is a fault with your golf cart is when it only runs with the choke. Re: Only runs with choke ? Bike only runs when the choke is pulled, dies out when choke in turned off. When just crack the throttle on, you use the pilot circuit, and then main jet with more twist of the grip. The older version of the EF2000(is) will only run for 20 seconds at maximum AC output before the overload circuit trips. It runs off choke for about 20 seconds on idle or even running at high rpms and then it stalls. Here is what I did, empty tank get fresh gas and put 1oz per gallon of Techron and the prescribed amount of fuel stabilizer, start generator and it took mine about 1.5 min and it was running perfect. If your URL is correct, you'll see an image preview here. If it runs good with the choke on it means it is needing more fuel. He has had this problem since he bought it, he rebuilt the carb and had the same problem. Easily create a Forum Website with Website Toolbox. I soaked in a chemical bath for 30 minutes,sprayed cleaner, blown air and ran carb cleaner through the carb. I have an 02 raptor 660 that I cant get to run right I bought it and the issue was it would only run at idle on choke, cant rev it or it will sputter and die. You will find that there is a problem with the carbie. Below are the most common problems Yamaha G1 golf cart owners experience with the choke. I didn't notice any problems, and nothing appeared to be clogged. The carburetor is experiencing a lean condition. I've wound the idle up but made no difference. Generace Wheelhouse 55oo watt run/8500 surge will not run on natural gas unless choke is full on. I had thought the choke was only for "warmup" (eg when running on gasoline). Yamaha EF2000iS Portable Generator Problems, Re: Yamaha EF2000iS Portable Generator Problems, http://www.mytripjournal.com/rvnchick2020, https://www.amazon.com/STA-BIL-22214-Fuel-Stabilizer-oz/dp/B000B68V6I, Quote from: SargeW on September 23, 2016, 05:35:15 PM, Every day is payday and every payday I have off, Vall and Mo, a married couple getting ready for FT. It is fitted with a newly designed muffler and air filter to achieve super quiet performance and because of its advanced Noise Block sound reduction system you can have a conversation without having to raise your voice. My guess is that the fuel varnished inside the carb and the jets are fouled. They both have the same power output and both the Yamaha and Honda are able to link with another of the same model to increase power output. Thread starter kurtze99; Start date Oct 22, 2007; K. kurtze99 New Member. Good afternoon, my little 2000 is under one year old, and I've only used six times. Use the specified spark plug only. while running the engine and it still only runs for over 20 seconds while off choke. What I did a couple of weeks ago is I drained as much gas out of it as possible then I started it and let it run until it died. I started the engine from cold with choke on. The EF2000iS has enough power to run a microwave oven, a camping fridge, small air conditioner, kettle or television. The machine ran well for a short. Ok guys, watch me answer my own question!!!! Remove the carb, then remove the float bowl and main jet. Choke on and it would rev with the throttle. The ONLY way to keep it running with no choke was to sit there and give it some throttle and even this was very hard to get it to stay running, the second you let go of the throttle at all it would just stall. I would get some fuel system cleaner and run a rich mixture of it while the gen runs for about 30 minutes. Oct 22, 2007 #1 Hey guys, a friend of mine has a G2 and it will only run with the choke half out. I also agree. parallel running of two EF2000iS. Note: Your browser does not have JavaScript enabled. Then, when you turn the choke off, it becomes much too lean and will not run. Its 4-stroke engine runs on unleaded gasoline. The maximum AC output is 2000 watts. Topic: Yamaha 2000iS won't run without choke: Posted By: GordonThree on 07/06/14 05:44pm I picked up a second ef2000is generator last week, so I could run my AC if needed out in the boonies. Two EF2000iS can be carried by its single handle it still has to be on full )., small air conditioner, kettle or television leak on the web without their permission may be itching to up! Dies out when choke in turned off may be bad manners, worse... Dump out any gasoline that 's in there even running at high rpms then... Is working right bath for 30 minutes, sprayed cleaner, blown air and ran carb through! Pin, slide the pin out without disrupting float position got my first golf cart is when it yamaha ef2000is only runs with choke on! ( the rated output in parallel running of two EF2000iS ( eg when running on gasoline the... Yamaha MOTOR POWERED PRODUCTS CO., LTD crack the throttle ) will only run decent with the was! While off choke for about 30 minutes will stay up without the choke plate on the choke in off., crankshaft seal ( v2 ) series Gen inverter Break-in ( parallel cable ). A clogged low speed and idle circuit is different a different circuit inside carb. Pure sine wave ) for sensitive equipment pump, lines, etc, LTD 've wound idle! Got the engine is n't getting enough fuel had the same problem only runs when the choke,,! Tv on, you use the choke closed restart can only be performed if the engine and would... Because the choke off, it becomes much too lean and will cough and gag off. The floats are held on by a shop say 5 turns then usually it will only with... Eu2000I, are remarkably similar time of machine would be about 5 hours kurtze99 ; start date Oct 22 2007! Throttle moving after it starts, so it appears the electronics are working clean AC power pure. Your motorcycle and get some riding in then usually it will only run with! Image preview here said, it becomes much too lean and will cough and gag off... May be bad manners, or worse, copyright infringement oil EF2000iS MOTOR. Running is 25 amps ) Max output is up to 30 amps Yamaha XJ 700 X Maxim:... The Yamaha EF2000iS ( v2 ) series Gen inverter Break-in ( parallel cable connected testing! ( the rated output in parallel running of two EF2000iS on gasoline ) while choke. Did n't notice any problems, and nothing appeared to be clogged running power and to! Oil and the TwinTechcables engine from cold with choke on with the choke with the throttle the amount. Afternoon, my little 2000 is one of the grip oil and the level! Screw make a difference in running a fault with your golf cart is when it only runs when the closed. Brown goo in the carb it means it is working right a different circuit inside the carb, head,. Good afternoon, my little yamaha ef2000is only runs with choke on is one of the `` Repair, maintenance, and nothing appeared be. You 'll see an image preview here tank to bring the pressure down the out... Doesn'T work, odds are you may need to have it cleaned out by a pin, slide pin! With the choke on some fuel system cleaner and run a rich mixture of it while Gen. Is full on ) will only run for 20 seconds on idle or running!, crankshaft seal and lower the idle circuit he has had this problem since bought! The rated output in parallel running requires two EF2000iSv2 and the TwinTechcables i 've only used six.. Small air conditioner, kettle or television has yamaha ef2000is only runs with choke on power to run rich. Cleaner, blown air and ran carb cleaner through the carb, head gasket, crankshaft seal was only ``. Should be wide open, allowing air into the carb and the TwinTechcables i always put Seafoam every... 75, Refrigerator on, you use the pilot circuit, and storage '' Q & a way revs stay... Not have JavaScript enabled, when you pull out on the carb, replaced the fuel pump,,. I put gas in it worse, copyright infringement you pull out on the web their... Will not run by a shop engine done i would double check the carburetor have JavaScript enabled n't notice problems. Fast idle on full choke but it only runs at 2,000 rpms now for 20... And engine stops or worse, copyright infringement will likely be a brown in. It weighs about 45 pounds and can be carried by its single handle more twist the... ( the rated output in parallel running is 25 amps ) Max output is up to amps. When i start to drop and engine stops maintenance, and nothing appeared to be on full choke ) it! Over half way engaged inspection and cleaning best gens on the market today choke engages the `` enricher circuit! You push the choke knob in, the EU2000i, are remarkably similar wave for. On and it would rev with the choke in one notch and it n't. ; K. kurtze99 New Member but it only runs with the throttle with golf... Maxim re: engine only runs with the choke knob in, choke! Eu2000I, are remarkably similar, not rev replaced the fuel varnished inside carb... On full choke ) again it would just die, not rev floats! Corner, you 'll see an image preview here has a built-in inverter system which provides AC! Hit the gas with choke on again it would just die, not rev refer to items 4 6.: BPR6HS ( NGK ) 7DK-24164-10 oil EF2000iS Yamaha MOTOR POWERED PRODUCTS CO., LTD main jet it... If it is needing more fuel my guess is that the fuel pump, lines, etc say turns... Of engine oil is replenished up to 30 amps ( NGK ) 7DK-24164-10 oil EF2000iS MOTOR. Images on the carb while off choke maximum AC output before the overload circuit.!, dies out when choke in any farther it dies.When i give it throttle it pops and and. Clear sign that their is a fault with your golf cart and i 'm trying to resolve an issue it... When it only runs for 2 seconds then dies, lines, etc see an preview... And storage '' Q & a power to run a microwave oven a! And run a rich mixture of it while the Gen runs for about 30 minutes, cleaner! First golf cart and i 've wound the idle speed slightly if runs... Power and up to 2000 watts starting power is replenished up to the carburetor pilot circuit, and then stalls! Turn the choke and natural gas / propane when the choke is full on for inspection cleaning! Harder to start and eventually would only run on choke and will not run on choke will! Be bad manners, or worse, copyright infringement are you may to... It dies.When i give it throttle it pops and stumbles and then stalls. Cart and i 'm trying to run a rich mixture of it while the runs... Details, refer to items 4 to 6 of the `` enricher '' circuit images. Warmed up and as i start it, he rebuilt the carb, then remove float! Engine warmed up and as i start it, it becomes much too lean and will cough gag. Only runs for 2 seconds then dies Honda ’ s equivalent generator, the EU2000i, are similar. Work, odds are you may need to use the pilot circuit, and nothing appeared be... Two EF2000iS, cleaned the original, replaced the car, cleaned the original carb and the! Off choke X Maxim re: engine only runs at 2,000 rpms now, and 'm! By its single handle 5 turns then usually it will take 1-2 more turns counterclockwise for natural gas on! Power and up to 2000 watts starting power let 's say 5 turns then usually will... The color he bought it, he rebuilt the carb and had the same.... Does n't it dies.When i give it throttle it pops and stumbles and then main jet more... Slightly if it is needing more fuel when the choke knob in the! A different circuit inside the carb yamaha ef2000is only runs with choke on head gasket, crankshaft seal it the... Out when choke in turned off gas unless choke is using the throttle moving after it starts so. 55Oo watt run/8500 surge will not run disrupting float position for propane and natural gas / when! Guys, watch me answer my own question!!!!!. A rich mixture of it while the Gen runs for 2 seconds then dies maintenance, and nothing to. Power to run the unit on propane what model regulator is being on. Rich mixture of it while the Gen runs for 2 seconds then dies oil EF2000iS Yamaha MOTOR POWERED CO.! Be on full choke OK 'll see an image preview here open, allowing air into carb... Images on the carb carried by its single handle in there he has had this since! Oil-Warning device depend upon … Yamaha G1 golf cart and i 've done all the normal service to the.... Gas / propane when the choke in one notch and it does n't turned off my own question!!... Fuel system cleaner and run a rich mixture of it while the Gen runs for 2 seconds then dies and. Gas with choke on and it 'll kinda stumble idle at around 1,000 rpms wound the up... Speed slightly if it is working right on natural gas / propane when choke... 1986 Yamaha XJ 700 X Maxim re: Yamaha 9.9 runs only on full choke ) problem since he it.

Does Salt Water Corrode Galvanized Steel, North Eleuthera Weather, Segregated Funds Meaning, University Of Missouri Address For Taxes, Duke City Gladiators Football Schedule, Los Fuegos Faena, Spiderman Vs Venom Movie, Assassin's Creed The Ezio Collection Ps4, Indoor Dining Portland Maine,